水泥撒布車新車在使用時要注意些什么？_公司新聞_新聞中心-山東途暢路橋工程有限公司

公司新聞

水泥撒布車新車在使用時要注意些什么？

來源：http:/// 日期：2021-10-13

1、新車開始使用時，必須進行全面檢查和試車，一切正常時，方可正式使用。

1. When the new car is put into use, it must be comprehensively inspected and tested. It can be officially used only when everything is normal.

2、輸送混凝土的容量，質量及塌落度應符合第二章中的規定。

2. The capacity, quality and slump of transported concrete shall comply with the provisions in Chapter II.

3、攪拌車在露天場地停放時，裝料前應先將攪拌筒反轉，把筒內的積水（或雨水）和雜物卸出，以保證運送混凝土的質量。

3. When the mixer truck is parked in the open field, the mixing drum shall be reversed before loading, and the ponding (or rainwater) and sundries in the drum shall be unloaded to ensure the quality of concrete transportation.

4、在出料斗、卸料溜槽旁工作時，要配帶防護用品。不要接近料斗及攪拌口，也不要向內窺看，更不得用手去摸旋轉的攪拌筒。

4. When working near the discharge hopper and discharge chute, wear protective articles. Do not approach the hopper and mixing port, do not look inward, and do not touch the rotating mixing drum with your hand.

5、在公路上行駛時，加長溜槽必須翻轉放置在卸料溜槽上用掛鉤掛牢，再轉至與車身垂直部位，用鎖緊裝置把卸料溜槽和加長溜槽鎖緊在機架上，防止由于不固定而搖動，造成傷人事故和影響其它車輛運行。

5. When driving on the highway, the extended chute must be turned over and placed on the unloading chute, hung firmly with a hook, and then turned to the position perpendicular to the vehicle body. The unloading chute and the extended chute shall be locked on the frame with a locking device to prevent shaking due to instability, resulting in personal injury accidents and affecting the operation of other vehicles.
水泥撒布車租賃

6、車穿越橋、洞、庫等設施時，必須注意通過高度的尺寸及路面承受重量以免損壞攪拌車。

6. When the truck passes through bridges, holes, warehouses and other facilities, attention must be paid to the size of passing height and the weight borne by the road surface to avoid damaging the mixer truck.

7、工作裝置連續運轉時間不應超過8h。

7. The continuous operation time of the working device shall not exceed 8h.

8、交貨時，如發現水分蒸發，塌落度偏低不能滿足用戶要求時，可適當向筒內加水，然后以12—14r/min的速度旋轉30轉后卸料。

8. During delivery, if it is found that the water evaporates and the slump is too low to meet the user's requirements, add water to the cylinder appropriately, and then rotate for 30 revolutions at the speed of 12-14r / min before unloading.

9、攪拌車在空載運行及運送混凝土過程中，攪拌筒不得停止轉動以免滾道、滾輪局部碰損或混凝土產生離析現象。

9. During the no-load operation and concrete transportation of the mixer truck, the mixing drum shall not stop rotating, so as to avoid local collision damage of the raceway and roller or segregation of the concrete.

10、水箱的水量要經常加滿，以備急用。

10. The water tank should always be filled up for emergency use.

11、水箱加水前，必須打開放氣閥把箱內空氣放掉，充氣供水后必須及時關閉貯氣筒。

11. Before adding water to the water tank, the vent valve must be opened to release the air in the tank. After inflating and supplying water, the air storage cylinder must be closed in time.

上一條：HF白灰撒布機在施工中要注意什么/

下一條：泡沫瀝青冷再生處理介紹